A lawnmower that hunts and surges may be experiencing something as simple as an airflow issue. If the air that the engine requires to run is blocked, especially sporadically, it can cause the engine to slow down. When the blockage moves or clears, the engine may suddenly rev up in response.
similarly, How do I know if my Briggs and Stratton coils are bad?
Start the mower when it is cold, and look through the window of the tester. Observe that there is a normal spark that allows the mower to run. One of the symptoms of a bad lawn mower ignition coil appears when you are mowing the lawn and the mower gets hot and literally shuts off.
on the other hand, Why does my lawn mower sound like it is surging?
The fuel tank cap has a small hole, which allows air to flow into the tank and create back-pressure to help deliver fuel to the carburetor. Dust or dirt can plug up this hole. As a result, the carburetor won’t get enough fuel, leading to surging. Surging can also occur due to water contaminating your fuel.
also, How do you adjust the governor on a Briggs and Stratton engine? To adjust the governor, you would loosen the screw on the bottom of the governor arm and push the governor arm so the throttle is wide open. Then you would turn the bottom “clip” (which is connected to the governor shaft) counter clockwise. This will set the governor shaft on top of the governor spool.
What are the signs of a bad ignition coil?
Ignition Coil Problems, Symptoms and Solutions
- Engine misfires.
- Rough idle.
- A decrease in car power, especially in acceleration.
- Poor fuel economy.
- Difficulty starting the engine.
- Check engine light is on.
- Exhaust backfiring.
- Increased hydrocarbon emissions.
What causes a lawn mower coil to go bad?
They are: Overheating. The operating temperature of the engine gets to hot and burns the coil out. This is not real common on a small engine as usually the engine will shut down from heat before the coil will fail, but it is possible.
How do you fix a surging idle?
Turn the engine off again, and reattach the air intake duct work to the throttle body. Start the engine and rev and hold to 1,500 to 2,000 rpm until no white smoke is coming out of the exhaust pipe. Cleaning the Idle Air Speed Control Valve with aerosol throttle cleaner can often solve an idle problem.
Can bad gas cause surging?
If an engine is not getting enough fuel (this is called “running lean”), due to fuel pressure (regulated by the fuel pump and regulator), restricted fuel injectors, a vacuum leak or really anything that throws off the fuel mixture going in to the engine, this can cause the surge.
What does car surging mean?
Surging is associated with a sudden increase in speed that occurs while trying to maintain a constant one. This is a sign that your fuel pump may have sufficient wear and tear and that its irregular resistance within the motor is creating an inability to maintain consistent pressure resulting in surges of power.
What does the governor do on a Briggs and Stratton engine?
The governor system is like a cruise control system. It maintains the speed of your lawn mower or outdoor power products. When Briggs & Stratton governors are adjusted properly, they keep your speed steady regardless of engine load – the amount of work the engine must perform.
What RPM does a Briggs and Stratton engine?
BRIGGS & STRATTON Gas Engine, 17.5HP, 3300 RPM, Vertcl Shaft – 1WVK4|31R907-0007-G1 – Grainger.
What does a bad ignition coil sound like?
Engine misfiring will be seen in a vehicle whose ignition coils have failed. Trying to start the engine of such a vehicle will result in engine misfiring that sounds like a coughing, sputtering noise. … A vehicle with a failed ignition coil will also result in vibration when it is idling at a stop sign or light.
Can an ignition coil get weak?
(Positive ground is the reverse.) Most ignition coils are long lasting and reliable, but a weak coil you can be the cause of under-hood havoc. … These kinds of coil problems are usually caused by heat and vibration. It is possible to have a sudden failure due to broken windings or bad connections inside the coil.
What causes small engine coils to go bad?
The leading cause of premature failure of an ignition coil is due to a worn or bad spark plug ignition cable. A bad spark plug ignition cable will have a much higher than normal resistance. This high resistance causes a very high amount of voltage to be generated from your ignition coil’s secondary winding.
Can an ignition coil go bad from sitting?
12 volts would kill them in short order but even at 7 they are becoming damaged every time the coil fires. It may seem odd to lead off with a short tutorial like that but when a car sits, that arcing damage on the point faces start to corrode. When the corrosion builds up the gap closes and the car won’t run.
What causes no spark on lawn mower?
Ignition Module Failure
When it does fail, it is usually due to heat caused from improper wiring of the ground wire to battery voltage. If the engine does not produce spark, other areas of the ignition system should be checked before focusing on the ignition module as source of failure (see above).
Can rough idle damage engine?
The downsides of a rough idle can be reduced fuel economy, poor performance, starting issues, or potential major engine problems in the near future. It is best to try to diagnose and fix a rough idle before it gets worse and before it gets expensive!
Why is my engine surging at idle?
If an engine is not getting enough fuel (this is called “running lean”), due to fuel pressure (regulated by the fuel pump and regulator), restricted fuel injectors, a vacuum leak or really anything that throws off the fuel mixture going in to the engine, this can cause the surge.
What causes rpms to fluctuate at idle?
Why does my engine’s RPM seem to fluctuate (runs rough)?
Many engine performance problems can be linked to maintenance issues such as stale fuel, dirty air filter, fouled spark plug, and deteriorated oil. … Engine hunting and surging at idle is usually caused by a fuel delivery, air leak, or governor system problem.
Can spark plugs cause surging?
3. Surging and Lagging. Another good indication that your spark plugs are dirty or worn is if your vehicle experiences surges of speed, resulting in a jerking acceleration. These surges occur because your spark plugs are not igniting the fuel in your engine at the proper rate, resulting in an uneven speed.
Can a bad O2 sensor cause surging?
Oxygen sensors are among the most interesting and important sensors on your engine. … Surging is among the many problems a failing O2 sensor can cause, but it isn’t the only one.
Why does my car feel like its surging?
If an engine is not getting enough fuel (this is called “running lean”), due to fuel pressure (regulated by the fuel pump and regulator), restricted fuel injectors, a vacuum leak or really anything that throws off the fuel mixture going in to the engine, this can cause the surge.
Is engine surging bad?
While an engine surge doesn’t cause your car to stop working completely, it can definitely negatively impact your fuel economy. Not only that, but the amount of emissions also tends to be much higher as well. Moreover, these effects tend to stack up over time when misfires happen more and more often.
Don’t forget to share the post !